Posted by binder300U on February 20, 2010 at 16:01:40 from (206.212.229.240):
I recently converted my 300u to a 12 volt system. It seems to be wired correctly, it starts, everything works, but to date i have fried two alternators! everything is fine for about 4 to 5 starts/runs- charging kicks in about 1500rpms. Then i start up the tractor, and suddenly it won't charge the battery(warning light stays on, no matter what the rpms).
electrical system components: original 6v delco starter with new 12v solenoid delco 4 pole ignition switch(came on the tractor when i got it) with poles for ACC, BAT, SOL, and IGN delco 12v coil delco 3 wire alternator new repro IH ammeter
wiring: (8ga)BAT post on alternator to (L) post on ammeter (8ga)wire from B post on ammeter to large post on solenoid (4ga)wire from same large post on solenoid to +battery terminal (1ga) wire grom -battery terminal to body (12ga)terminal 1 on alternator to ACC on ignition switch thru warning light- tho wires into and out of the warning light are 16ga (12ga)terminal 2 on alternator to BAT on alternator (14ga) SOL on ignition switch to small post on solenoid (12ga) BAT on ignition switch to (L) post on ammeter (12ga) IGN to + post on coil (12ga)light switch to (L) post on ammeter (12ga)cigar lighter to power out(always hot) on light switch
One thing i noticed when the alternator charges- the ammeter needle sits all the way at the top of the gauge at first, then drops down to about 2/3 up the gauge.
anyone have any insight into what the prob cold be? thanks alot.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - The Niagra View Mobile - Powered by a 1959 Ford Tractor - by Mark Massey. In 1959 the Niagara Frontier Transit Inc. of Buffalo, New York designed and built six Viewmobiles for the Niagara Frontier Sightseeing Inc. for use as a sightseeing ride at the Niagara Falls State Park, Niagara Falls, New York, powered by a 1959 Ford 611 Tractor.
... [Read Article]
Latest Ad:
Oliver 550 Diesel runs like a watch three point hitch pto engine gone threw about two hundred hours ago nice clean tractor
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
