I suppose you can have TWO "good" junkyard alternators both suddenly fail though it seems kinda unlikely. For the price for a fresh rebuilt alternator ($40 or so) you might be ahead to get one instead of another junkyard unit.
However a healthy alternator will be ruined if the charge circuit (alternator BAT to ammeter to battery positive) goes open while it's charging - if even for an instant. Also if the sensing circuit (wiring to the #2 terminal) goes open while running. So I'd suggest double checking all wiring for good tight connections - including the battery cable terminals
---
As for determining exactly what's failed on a dead alternator here's a couple things to check:
1 - With the engine running at 1/2 throttle bypass the regulator by grounding shorting tab inside the back of the alternator. If it now charges hard the regulator has failed.
2 - If you have a VOM or DMM set the meter on the lowest ohms range. Now disconnect all wiring from the alternator and take a resistance reading between the BAT terminal and the case. Note the reading then reverse the meter probes and measure again.
A "good" reading is infinite resistance with the probes one way and very low resistance with the probes reversed.
Infinite ohms in both directions means an open circuit in either the stator or diode bridge. Low ohms in both directions is a shorted bridge. Only fix for either is to replace with new.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Choosin, Mounting and Using a Bush Hog Type Mower - by Francis Robinson. Looking around at my new neighbors, most of whom are city raised and have recently acquired their first mini-farms of five to fifteen acres and also from reading questions ask at various discussion sites on the web it is frighteningly apparent that a great many guys (and a few gals) are learning by trial and error and mostly error how to use a very dangerous piece of farm equipment. It is also very apparent that these folks are getting a lot of very poor and often very dangerous advice fro
... [Read Article]
Latest Ad:
Sell 1958 Hi-Altitude Massey Fergerson tractor, original condition. three point hitch pto engine, Runs well, photos available upon request
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.