Posted by JimS on February 15, 2014 at 15:30:25 from (209.148.97.151):
I have an older (mid 90s?) JD 4x6 diesel Gator
Currently, it is popping out of gear; always uphill, usually under load, only in forward. I tried adjusting the linkage and that helped a little, but not much. I removed the linkage completely and shifted by hand and it still does this. When I shift, there is a loosness that is not to be had on my other Gator. Also, I can notice the shaft that the clutch is on moves in and out a bit. THis does not occur on my other Gator.
I assume a rebuild is required, but the manual does not indicate what is likely to be wrong and therefore, what parts I might need.
I assume. if I am going this far, I should replace the brake discs in the transaxle
There does not seem to be a great deal of difference in transaxles from model to model; can I simply swap tranaxles?
Any constructive thoughts or ideas on this matter will be appreciated.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Engine Valves - Some Helpful Information - by Staff. Intake - On the intake stroke the piston moves doward, sucking in carburized fuel through the open intake valve. Exhaust valve is closed. Compression - With both the intake and exhaust valves closed, the pistons upward stroke compresses or squeezes the fuel into the combustion chamber. Firing - Ignited by the spark, the compressed fuel explodes and forces the piston downward on its power stroke. Intake and exhaust valves are closed. Exhaust valves and seats are exp
... [Read Article]
Latest Ad:
Oliver 550 Diesel runs like a watch three point hitch pto engine gone threw about two hundred hours ago nice clean tractor
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.