Posted by John T on November 06, 2011 at 05:45:00 from (173.243.181.15):
In Reply to: Elementary Electrical posted by equeen on November 06, 2011 at 05:21:11:
I think Bob M has a good picture of that switch and what wires go where, I'll let him or others handle that part of your question and I'll just address this one:
3. Alternator #1 spade switch wire to ignition. Wiring options appear to include somewhere along the length of the wire: A filament style marker lamp bulb, or A 15 ohm resistor, or A 3 amp 50 volt PIV diode
Of course I could be confused with the above, but my question remains...... What is the purpose of something in this stretch of wire?
ANSWER:
OKAY, voltage is required to the No 1 terminal (on the GM 3 wire 10 SI alternator family) in order to "excite" the alternator prior to sufficient RPM such that it becomes self "excited"
So, why a diode or resistor or incandescent idiot light???
One or more of those are required becasue if you feed that No 1 terminal from the ignition system, like the IGN output on an ignition switch or the high input (NOT to distributor) side of the coil or the high input (NOT to coil) side of a ballast resistor THE TRACTOR MAY CONTINUE TO RUN AFTER YOU TURN THE IGN SWITCH OFF because the alternator might still back feed the coil i.e. independant from the ign switch.
NOTE Ive seen this work with no resistor at all in that wire, it depends on the idle RPM and other factors but many tractos would run on without this feature
I suggest either an incandescent lamp or a resistor as they provide at least some small degree of current limiting versus use of a diode like most use. Also an idiot light (small incandescent tail marker) provides a visual indication if shes charging or not the diode or resistor cant. Also some "dudes" use an idiot light in paralell with a resistor so the alternator still excites even if the lamp burns out.
NOTE some dudes (like if its a diesel) rig up an oil pressure switch and use it to excite the alternator verus the ignition but id still sue a resistor to give soem degree of current limiting.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Choosin, Mounting and Using a Bush Hog Type Mower - by Francis Robinson. Looking around at my new neighbors, most of whom are city raised and have recently acquired their first mini-farms of five to fifteen acres and also from reading questions ask at various discussion sites on the web it is frighteningly apparent that a great many guys (and a few gals) are learning by trial and error and mostly error how to use a very dangerous piece of farm equipment. It is also very apparent that these folks are getting a lot of very poor and often very dangerous advice fro
... [Read Article]
Latest Ad:
Sell 1958 Hi-Altitude Massey Fergerson tractor, original condition. three point hitch pto engine, Runs well, photos available upon request
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
