Posted by JBann on October 02, 2009 at 16:28:45 from (70.44.147.219):
Well guys,
I really only have one problem. The engine is surging at any speed, idle, full throttle and anything in between. Surging gets worse as engine speed increases.
The engine did not surge/gallop before when I first started it (after cleaning it and changing all the gaskets and fluids since it sat for a while) and the first day. I also have little control over engine speed with the hand throttle. In order to try and fix the lack of throttle control that I had, I took off the governor just to see what condition it is in. I cleaned it and oiled it and put it back on. (I also made sure that the linkage to the carburetor is inline with the throttle linkage.)
Ever since it has been surging. I can see the governor arm going back and forth and the linkage to the carburetor.
Pulling the choke doesn't do anything, so I don't think the carburetor is blocked or something, esp. since it ran perfectly before.
I tried to adjust the bumper spring in the governor, but I sadly couldn't budge it with the governor still on the tractor. Is it supposed to be that hard to turn? I'll have to take the governor off and try turning the spring in (service manual says this can possibly stop engine galloping)
Has anyone had problems like this before and have some advise?
Thanks everyone, I am learning as I go, and the manual/service manual isn't the most descriptive or specific help.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - The Niagra View Mobile - Powered by a 1959 Ford Tractor - by Mark Massey. In 1959 the Niagara Frontier Transit Inc. of Buffalo, New York designed and built six Viewmobiles for the Niagara Frontier Sightseeing Inc. for use as a sightseeing ride at the Niagara Falls State Park, Niagara Falls, New York, powered by a 1959 Ford 611 Tractor.
... [Read Article]
Latest Ad:
Oliver 550 Diesel runs like a watch three point hitch pto engine gone threw about two hundred hours ago nice clean tractor
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
