THere are two possible realities. THe first is that the battery could have a bad cell. This is possible even with a new battery. The second is that the alternator could have a bad primary diode allowing voltage to flow back into the stator windings.
One wire systems are somewhat less problemfree when compared to the 3 wire Delcos, or Hitachi.
Three system checks are needed. The first is to determine the actual charging voltage. Running at High Idle (wide open) check the battery voltage across the battery terminals (use a analog meter if possible, they are better when looking at old unshielded machines) The charge voltage into a fully charged battery should be between 14.2, and 14.7 volts. Anything over 15 volts is an issue with the internal regulator in the alternator. If OK, check the discharge of current into the alternator (bad diode as above. With it not running, and all wires connectd, remove the wire connecting the alternator to the wiring harness at the alternator, be careful, this wire is connected to the battery and cannot be touched to grounded things. (doing this at that location reduces the chance of making a spark where hydrogen could be found near the battery. If this wire makes a spark when touched to the post you took it off of, the diode bridge in the alternator is bad. If it does not spark, use a test light (not the meter) to see if current is flowing between the wire and the terminal you removed it from. The light should connect to the wire, and be touched to the terminal. If no light, not even a glow, the diodes are probably OK. Next check the battery (a hydormeter (specific gravity reading of each cell is great, they should be equal in specific gravity from cell to cell, and represent the state of charge of the battery from a chart) OR after running check the temperature of each cell with a glass thermometer to determine differences. Be careful with acid. The temps should be just a bit higher (10 to 15 degrees in the center cells, and a bit less on the two end cells due to being exposed to more outside cooling. If celld are 30 to 50 degrees or more different, the battery is bad. Good luck, and keep us informed as to what you find. JimN
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Box Plow Blues - by Tom Schwarz. One of the first implements most tractor owners obtain is the box plow. For very little money, this piece of equipment promises to plow and flatten any hill or vale on your ranch road or farm. At least that's what I thought! As simple as a box plow appears, it can be rather challenging to make work correctly. In our sandy soils of Florida, traction is king. You can never have wide enough tires or heavy enough weights to get all the traction you want … unless you own a monster tractor. U
... [Read Article]
Latest Ad:
Oliver 550 Diesel runs like a watch three point hitch pto engine gone threw about two hundred hours ago nice clean tractor
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
