Posted by Owen Aaland on June 28, 2010 at 00:51:47 from (65.165.246.5):
In Reply to: 1586 steering pump posted by Moline_guy on June 27, 2010 at 17:17:30:
Actually there will be no or very little oil flow to the rear in any of those tractors at low idle. You have a 12 GPM pump at rated speed, 2400 - 2600 RPM. When you drop to low idle at around 800 RPM you are running only 1/3 the rated speed. As a result the pump is also only going to flow 1/3 as much. That gets it down to about 4 GPM, less than the orifice will flow so all the oil goes to the steering. This really is not a problem since the tractor is not able to put much stress on the drive train at low idle.
The reason for testing at low idle is because by turning the steering all the way to stop in either direction it causes the oil pressure in the system to rise from about 250 PSI to 1800 - 2100 PSI. A weak pump will not flow enough oil at those pressures at idle and as a result the TA lube light will come on, the TA will down shift, or you will notice loss of braking assist. If the pump passes at idle it will be serviceable at higher RPMs.
The problem you have is air getting into the suction side of the system, most likely the seal ring between the center section and the rear frame. The MCV pump is completely submerged so the air is not entering there. Installing a new pump may help because it will be a little better at moving the air out of the system but it will not repair the main cause of the problem. On your tractor with the supercharge line it may help if you do not move either the hitch or the auxiliary valve until it has purged.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - The Day Mom Drove the 8N - by Brian Browning. My Dad was wanting to put in a garden but couldn't operate the 8N and handle the old horse drawn plow he had found and rigged up to use with the tractor. Well, he decided to go get Mom out of the house and have her drive the tractor while he walked behind the plow. You got to understand that while my Mom is a hard worker who will always help whenever she can... she had never operated farm machinery before that day. Dad got her out there, explained how the clutch was the same as in our o
... [Read Article]
Latest Ad:
Oliver 550 Diesel runs like a watch three point hitch pto engine gone threw about two hundred hours ago nice clean tractor
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.