Tractor Talk Discussion Board |
Re: Glowplugs in diesel tractors...
[ Expand ] [ View Follow Ups ] [ Post Followup ] [ Return to Forum ]
Posted by Ron on May 30, 2004 at 03:08:08 from (69.179.2.158):
In Reply to: Glowplugs in diesel tractors... posted by Jeremy Cope on May 29, 2004 at 23:38:55:
The entire operating principle of a diesel engine is that when you compress a gas, you heat it. In a diesel, the gas (air) is mixed with fuel and due to the high compression ratio (14:1 - 30:1) so much heat is put into the cylinder the air/fuel mixture self-ignites. As far as starting goes, many old diesel engines had no starting aid. In warm weather, with lots of heat in the air, they started fairly easily. In cold weather, getting them started caused a lot of new cuss words to be invented. Later, things like ether squirted into the intake manifold (dangerous but effective) and intake air preheaters (think the heating element in a toaster) were used. Then came glow plugs. Ask your relatives and I'm sure they will tell you that getting a diesel started, especially in cold weather, is dependent on four things: 1) The starting system must be perfect... batteries, cables, starter. 2) The injector pump and injectors must be perfect. 3) Injector pump timing must be right on the money. 4) You must be using the right fuel and it must be free of water. I've learned that in a very cold climate, block heaters and synthetic oil are very helpful.
Follow Ups:
Home
| Forums
Today's Featured Article -
The Nuts and Bolts of Fasteners - Part 2 - by Curtis Von Fange. In our previous article we discussed capscrews, bolts, and nuts along with their relative hardness and thread sizes. In this segment we will finish up on our fasteners and then work with ways to keep them from loosening up in the field. Capscrews, bolts and nuts are not the only means of holding two parts together. When dealing with thinner metals like sheet tin, a long bolt and
... [Read Article]
Latest Ad:
Oliver 550 Diesel runs like a watch three point hitch pto engine gone threw about two hundred hours ago nice clean tractor
[More Ads]
Copyright © 1997-2024 Yesterday's Tractor Co. All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V. Yesterday's Tractors - Antique Tractor HeadquartersWebsite Accessibility Policy |
|