Posted by jon f mn on November 23, 2023 at 17:32:40 from (174.199.35.80):
One of the husking rollers on my picker had gotten so worn it wouldn't pull the husks off, which caused them to hang up and plug the husker. So I decided to rebuild the one causing the problems. The hardest part was getting the bolts out of the bearing holder. Had to reach behind that channel to get a wrench on the nut.
Worse yet, it was all deep in the wagon elevator.
Wouldn't have been a bad job if I had an extra elbo and wrist in my left arm. Lol. Eventually I got it, then everything else came apart easy. The old rubber was a series of discs that looked like they were cut from a tire. These are some old nes.
So to replace them I used a hole saw on some tires to make discs.
To cut the square hole I used a thin wall square tube and sharpened one end. A few whacks with a mall cut a nice square hole.
In this ic you can see the size difference. You can also see how the old ones had worn smaller than the end pieces which kept the rubber from grabbing the husks properly.
Took over 100 discs to redo the roller. Looks like it's going to work well now.
Hopefully will get my corn picked this weekend with it.
Upload one or more videos to your post. Photo and video filesizes should be less than 5MB. Formats allowed are gif, jpg, png, ogg, mp4, mov, and avi. Be sure to use filenames without spaces or special characters, and filetypes of 3 digits lower case.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - History of the Nuffield Tractor - by Anthony West. The Nuffield tractor story started in early 1945. The British government still reeling from the effects of the war on the economy, approached the Nuffield organization to see if they would design and build an "ALL NEW" British built wheeled tractor, suitable for both British and world farming.
... [Read Article]
Latest Ad:
Oliver 550 Diesel runs like a watch three point hitch pto engine gone threw about two hundred hours ago nice clean tractor
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.