Posted by BarnyardEngineering on October 25, 2021 at 14:53:18 from (76.179.209.4):
I've posted on this Club Car before but I've made ZERO progress with it despite changing everything in the ignition system and fuel system.
Every time I change a component, I step on the pedal and VROOM! It comes to life instantly and runs like a top. For a time. Maybe minutes. Maybe a couple of days. Then it's back to its old tricks, just sitting there crank-crank-crank, sometimes eventually starting. Maybe choke helps. Maybe not. No rhyme or reason to it. I can choke it and it will fire and I can hold the choke and it just sits there crank-crank-crank.
It has:
1. New ignitor and rev limiter.
2. New ignition coil.
3. New spark plug.
4. New fuel lines and fuel filter.
5. New fuel pump.
6. New carburetor (the final straw).
NONE of these replacements was at random. They were all done after troubleshooting and doing research and following the symptoms. It's had every symptom. No spark.
I pull the fuel line off the carb and crank it, fuel SPRAYS out the hose. So the pump is working and the carb is getting fuel.
I pull the spark plug, and it has bright blue spark.
I open the drain on the carb and fuel runs out in a steady stream so there is fuel in the carb.
The thing it's doing now is after I open the carb drain and "blood let," it fires right up and runs perfectly... for about 3 seconds. Then I "blood let" it again, and it runs perfectly... for about 3 seconds. It will do this as many times as I drain fuel from the carb.
Can someone please clue me in on what is going on? I've gone round and round with troubleshooting and replacing parts and troubleshooting and replacing parts, and there's nothing left to troubleshoot and replace.
Upload one or more videos to your post. Photo and video filesizes should be less than 8MB. Formats allowed are gif, jpg, png, ogg, mp4, mov, and avi. Be sure to use filenames without spaces or special characters, and filetypes of 3 digits lower case.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - The Day Mom Drove the 8N - by Brian Browning. My Dad was wanting to put in a garden but couldn't operate the 8N and handle the old horse drawn plow he had found and rigged up to use with the tractor. Well, he decided to go get Mom out of the house and have her drive the tractor while he walked behind the plow. You got to understand that while my Mom is a hard worker who will always help whenever she can... she had never operated farm machinery before that day. Dad got her out there, explained how the clutch was the same as in our o
... [Read Article]
Latest Ad:
Oliver 550 Diesel runs like a watch three point hitch pto engine gone threw about two hundred hours ago nice clean tractor
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
