Posted by Bob in SD on March 20, 2018 at 12:14:15 from (137.216.209.56):
Hi All,
This one has me stumped. 20006 1/2 ton with a manual five speed. Occasionally, especially when warm, it's very difficult (as in almost impossible) to put into first gear when stopped. When this happens, it won't go into any gear (so you can't use 2nd to line up the gate).
Also, at least sometimes, if I push in the clutch and put it into gear a terrible rattling sound starts. It sounds like chains rattling and continues even if I take it out of gear for as long as the clutch is in. I haven't had a chance yet to go underneath and figure exactly where the noise is coming from (it sounds further back than the tranny, but I have a topper on and it's probably echoing off of that. It's got to be tranny or clutch, right?). Again, this is with the truck stopped, clutch in, and doesn't start until I put it in gear.
Any ideas? Any chance a sticky throw-out bearing could cause these issues? Hoping to avoid putting a new tranny in a 16 year old truck. Miles are low (about 150k).
Upload one or more videos to your post. Photo filesizes should be less than 300K and Videos, less than 2MB. Formats allowed are gif, jpg, png, ogg, mp4, mov, and avi. Be sure to use filenames without spaces or special characters, and filetypes of 3 digits lower case.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - History of the Nuffield Tractor - by Anthony West. The Nuffield tractor story started in early 1945. The British government still reeling from the effects of the war on the economy, approached the Nuffield organization to see if they would design and build an "ALL NEW" British built wheeled tractor, suitable for both British and world farming.
... [Read Article]
Latest Ad:
Oliver 550 Diesel runs like a watch three point hitch pto engine gone threw about two hundred hours ago nice clean tractor
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.