Posted by John M on August 22, 2016 at 15:45:46 from (67.231.165.179):
Since figuring out the electrical gremlins on my ZTR, I have a new one. Ill try to explain the best I can. 2 tanks, hold 5 gallons each. M=Mower got to where it would only run 10 minutes or so, and then just die. If I was fast enough to kill the deck, and move the choke to about 3/4, I could make it back to the building. Almost the exact same time, the engine on my other ZT started having very similar symptoms, and after investigation, I found water in my gas can. (Still not sure how that happened)I drained and cleaned out the tank on ZTR #2 and all is fine. On the first one, I drained the fuel, and sure enough, water in the fuel. I took both tanks off and have let them sit in the sun, and are dry. I replaced the fuel lines, since they were off, and getting old, as well as a new fuel filter. I removed the carb and cleaned what little gunk was in there, which wasn't anything more than a little drop of water or two. I also removed and checked the valves, which were fine. After getting it all back together, I put a couple of gallons in each tank. The engine started, and ran fine, so I let it sit for a few minutes, and it never missed a beat. So I get on, head to the yard, make 2 rounds and it starts dieing again. I managed to get it back to the building, and keep it running by choking and playing with the throttle, but I did notice that the filter had no fuel in it. Not just a little, NONE. If I choked it, fuel would pull into the filter and it would stay running. It finally got to where it would no longer stay running, but I sat there for a few seconds and watched the filter and the fuel slowly filled the filter back up. I can take the lines loose, and blow through the lines fine, plus with them being new, I don't think they are the problem. I can take the line loose at the pump and have feul coming out the line to the carb, and it does push fuel when I turn the engine over, but no real force behind it.
My next step was to check for spark. When the engine finally died, I pulled the wire on each cylinder and I have a good blue spark on each side. I cant even think its electrical, as choking helps for a moment, so I'm thinking the fuel pump isn't pulling the fuel FROM the tank to keep it running. Opinion?
Upload one or more videos to your post. Photo filesizes should be less than 300K and Videos, less than 2MB. Formats allowed are gif, jpg, png, ogg, mp4, mov, and avi. Be sure to use filenames without spaces or special characters, and filetypes of 3 digits lower case.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - The Nuts and Bolts of Fasteners - Part 2 - by Curtis Von Fange. In our previous article we discussed capscrews, bolts, and nuts along with their relative hardness and thread sizes. In this segment we will finish up on our fasteners and then work with ways to keep them from loosening up in the field. Capscrews, bolts and nuts are not the only means of holding two parts together. When dealing with thinner metals like sheet tin, a long bolt and
... [Read Article]
Latest Ad:
Oliver 550 Diesel runs like a watch three point hitch pto engine gone threw about two hundred hours ago nice clean tractor
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
