Posted by Jiles on October 16, 2014 at 09:39:12 from (69.137.29.28):
I have a Case 480D backhoe. Starter drive was slipping and a new drive could not be found. A new starter was close to $300.00 so I decided to take a chance on a Chinese made replacement. I installed the $125.00 communist made junk starter and the solenoid was clicking sometimes and was getting worse. I removed and cleaned contacts, although they looked good, and it was virtually the same design but much smaller, but it started well for a short time.
Now it will "click" once in about five starts and I can short contact wires at starter and it starts instantly every time.
I replaced the ignition switch and the solenoid wire going to the starter.
Same problem but will always start by shorting solenoid.
All contacts are clean and bright and fit snug.
Really reluctant to pay upwards of $300.00 for a new starter and still have the problem!
I was not having a solenoid problem with original starter.
Just doesn't make sense that it will start by shorting but not with ignition switch. In all my repairs, this problem was always ignition switch or it's wiring.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Engine Valves - Some Helpful Information - by Staff. Intake - On the intake stroke the piston moves doward, sucking in carburized fuel through the open intake valve. Exhaust valve is closed. Compression - With both the intake and exhaust valves closed, the pistons upward stroke compresses or squeezes the fuel into the combustion chamber. Firing - Ignited by the spark, the compressed fuel explodes and forces the piston downward on its power stroke. Intake and exhaust valves are closed. Exhaust valves and seats are exp
... [Read Article]
Latest Ad:
Oliver 550 Diesel runs like a watch three point hitch pto engine gone threw about two hundred hours ago nice clean tractor
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
