You need three things to make this system to charge. 1) Stator output between 24 and 30 volts AC checked across the wires from the stator.
2) The regulator/rectifier has to be well grounded. The engine has to be grounded to the frame as well. ( Had one giving me fits until I found a bad engine ground strap.)
3) Battery voltage at the middle terminal on the voltage regulator. One volt lower than the battery is the max for it to work.
You did not tell us what the motor is being used on. I am most familiar with them on the older JD lawn tractors. The biggest cause of charging trouble was either the key switch being bad or the plug on the back of it corroded where the voltage regulator did not get battery voltage.
I worked on these things for many years I only saw maybe one or two bad stators. Never had a flywheel bad. Switches where the most common issue and then regulators after them.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Women and Tractors - More Views From the Farmer's Wife - by Teri Burkholder. The top ten reasons why the judges wouldn't let you participate in the stock antique tractor pull: Hey, this is stock! It came with that V8 in it! That "R" on my tires stands for "really old" not radial! Blue gas? We thought it was a pretty color! What wire hooked to my throttle?
... [Read Article]
Latest Ad:
Sell 1958 Hi-Altitude Massey Fergerson tractor, original condition. three point hitch pto engine, Runs well, photos available upon request
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
