Posted by Ken Macfarlane on January 30, 2012 at 03:43:38 from (156.34.142.102):
I've got a turbo perkins in my Massey with 4300 hrs, it works fine, and works fine under load with the following exceptions:
-It has a hunting idle, it will just wander up and down, especially if you disturb it a bit by starting to move a bit them pushing the clutch in, then steadies out over several minutes. While doing this it almost stutters like its missing.
-When the engine comes into a load, it will sort of stumble for a sec then catch itself and sometimes overshoot the rpm it should be at. An example is running the haybine in a hilly field, it will be fine cutting accross the slope, then when turning up hill it will lose 200 rpm in the first couple of secs, then surge ahead and overshoot by 200 rpm the next few secs, then fall back to the set rpm while making the stuttering/missing sound like it does at idle. Basically it doesn't like transitions in power output.
I've not done much work with diesel motor or turbos, but my brains is saying there shouldn't be anything that causes missing under load like this. It would seem to be related to the governer or some type of boost regulator, but I still don't see how to make it stutter under load.
If it was a change in fuel flow causing air to get sucked in, it should be on the supply side of the pump and should be a delay instead of so instant, and should cause a problem at full fuelling. But the thing will pull fine at full power once it gets stabilized.
Does the governor change the timing in the injection pump?
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - The Niagra View Mobile - Powered by a 1959 Ford Tractor - by Mark Massey. In 1959 the Niagara Frontier Transit Inc. of Buffalo, New York designed and built six Viewmobiles for the Niagara Frontier Sightseeing Inc. for use as a sightseeing ride at the Niagara Falls State Park, Niagara Falls, New York, powered by a 1959 Ford 611 Tractor.
... [Read Article]
Latest Ad:
Oliver 550 Diesel runs like a watch three point hitch pto engine gone threw about two hundred hours ago nice clean tractor
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.