Posted by oldtanker on September 21, 2011 at 08:54:40 from (66.228.255.223):
In Reply to: Fuel Problem posted by Dennis (VA) on September 21, 2011 at 07:49:45:
OK a mechanical fuel pump has a diaphragm in it to both create vacuum (suction) and pressure. It also has 2 check valves. When on the suction stroke it pulls the pressure or out side valve closed and sucks the intake side open pulling gas into the chamber. On the pressure stroke it sucks the intake side closed and when it builds enough pressure pushes the out put side open sending gas to the carb. If one or both of the valves is bad it may still work but not well and can take a little time to prime itself. It can also allow gas to drain back into the tank from the lines and pump. It will not siphon gas out of the carb becasue of the design of the carb. Gas enters the carb through the needle and seat that is controlled by the float. Every carb I've worked on has the needle and seat in the top cover and there is no direct line or tube into the gas in the bowl from the fuel line.
So take the air cleaner off and with the choke plate open manually operate the throttle lever while looking down the throat. You should see gas squirting into the throat on a car of truck engine. If not the bowl may be empty showing a fuel supply issue or the accelator pump in the carb is bad. If it kinda just dribbles the accelerator pump is bad or they is a plugged passage in the carb. If as you say the bowl is empty then you have a carb issue that will require rebuilding or replacement. You can check that by disconnecting the fuel line at the carb. If it starts to dribble and or squirts gas as you are taking it off stop. You can test the fuel pump by taking that fuel line at the carb and installing a fuel presure gauge (smart safe way) or just leave it off and bump the starter. If you get pressure or gas pulses while cranking right away you have eliminated the fuel pump.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - The Tractor Parade: Story of a Case SC - by Bernie DeLon. On a early fall morning back in 1994, I opened the newspaper and happened to spy an article about a local antique tractor club having their annual show that weekend.
... [Read Article]
Latest Ad:
Sell 1958 Hi-Altitude Massey Fergerson tractor, original condition. three point hitch pto engine, Runs well, photos available upon request
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
