Ok, thank you so much for everyones input, I took what I could from each person, implemented a little from everyones advise, and we got it fired up. No we got a slight problem with the running part. Here are it's symptoms;;
1) wont start unless you shoot a little either to it, even if its just shut off
2) smokes bad when idle, no smoke when full throttle
3) sluggish to idle up
4) you hear a knocking noise coming from the motor every 4-7 seconds that last about 1.5-2 seconds. When its making this noise, it plums black smoke, pops back thru the air intake however motor seems to balance out.
5) it runs with a mis, however when I loosen up each injector I still hear a major difference, so I cant pin point the injector that doesnt seem to be firing.
6) as odd as this sounds, when the motor is running, it dont hammer like a diesel engine, sounds more like a 4 stroke engine running. The only time you hear it sound like a diesel is when the black smokes plums out and you hear the noise change, and it pops back thru the air intake.
7) now I know some of you are going to tell me to adjust the timing a bit by twisting the pump...DID it already, all the way one way then back again, 1 deg at a time, get more smoke or less, but the popping still occurs, and this mis dont go away....So Im up again for some suggestions, were getting closer!!!!!
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Engine Valves - Some Helpful Information - by Staff. Intake - On the intake stroke the piston moves doward, sucking in carburized fuel through the open intake valve. Exhaust valve is closed. Compression - With both the intake and exhaust valves closed, the pistons upward stroke compresses or squeezes the fuel into the combustion chamber. Firing - Ignited by the spark, the compressed fuel explodes and forces the piston downward on its power stroke. Intake and exhaust valves are closed. Exhaust valves and seats are exp
... [Read Article]
Latest Ad:
Oliver 550 Diesel runs like a watch three point hitch pto engine gone threw about two hundred hours ago nice clean tractor
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
