Hi, simple thing first, leaking return line, this is a common problem, the part is still available from caseih. Make sure return line back to fuel tank is not blocked.
Raw Diesel leaking from exhaust port on cylinder 1 & 4, this is called Diesel slobbering, caused by few reasons, engine is not up to temp, engine idling too much and over fueling. If you look at the photo that I borrowed off the web, you see the label "Fuel control lever" and there is an adjustment screw that limits the the fuel control lever. This adjustment screw is called the power screw and the more that it is screw out allowing the fuel control lever to open more, the more HP the the engine produces up to a max of about 70 HP when the fuel control lever limits on the power screw mounting bracket.
What may have happened is some previous owner may have opened the power screw to the max over fueling the engine.
Another method to reduce slobbering if engine is just idling around is don't pull the STOP/START/RUN lever all the way to the top of the RUN position. This has the effect of not opening the fuel control level on the pump all the way and therefore injecting less Diesel into to the cylinder.
BTW most Diesel engines like to be worked hard and the slobbering will disappear.
As for the other leaks in the pump DieselTech is the expert.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - George's Fordson Major - by Anthony West (UK). This is a bit of a technical info to add on to the article about George's Major in the "A Towny Goes Plowing" article. George bought his Major from a an implement sale about 18 years ago for £200.00. There is no known history regarding its origins or what service it had done, but the following work was undertaken by Harold alone to bring it up to show standard. From the engine number, it was found that the major was produced late 19
... [Read Article]
Latest Ad:
Oliver 550 Diesel runs like a watch three point hitch pto engine gone threw about two hundred hours ago nice clean tractor
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.