Have two H's, both workers, both converted to 12 volt w/ one wire alternators. (smaller Hitachi's) Both on Magnetos. One is standard bore, new pistons and sleeves and is in top shape. The other has firecrater pistons and is also in top shape, averaging 145lbs per cylinder. Both start great, and have had NO problems with batteries or magnetos plus I have much brighter lighting now.
On the magnetos "turning too fast" with a 12v starter, it was explained to me that the impulse performs two functions. 1st, and foremost as far as safety is concerned, it retards the spark to avoid engine kickback at low (handcranking) speeds. 2nd, it spins the armature over more quickly to ensure a "hot" spark at low cranking speeds.
Once the engine has reached an rpm over 200-250, the magneto is producing adequate spark w/o the impulse's assistance, so the impulse is disengaged by the centrifugal effect of the pawl design.
That being the case, IMHO, if the starter is spinning the engine over fast enough to disengage the pawls, there is no issue, as its making enough spark and there is enough flywheel inertia to carry the pistons over tdc and not "kickback" . If it is not spinning it fast enough to disengage the pawls, (so you're hearing the click click click of the impulse tripping) and it still isn't starting, you have other issues to address. If it starts quickly, and the impulse only clicks a couple of times, I doubt much more wear will occur than starting it on a 6v system that trips it several times before starting.
again, just my opinion. No warrantees implied or expressed.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Talk of the Town: Repairin a Gas Tank - by Staff. This interesting discussion is from the Tool Talk Discussion Forum. Remember that safety is your first priority - make sure you know what you are doing before attempting a potentially dangerous activity!
... [Read Article]
Latest Ad:
Sell 1958 Hi-Altitude Massey Fergerson tractor, original condition. three point hitch pto engine, Runs well, photos available upon request
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
