Thanks for the alternator info Jim! (I'm not familiar with the 140 family...)
----
Here's how to check the alternator on the tractor:
1 - Check resting voltage: Pull the aux (2 wire) connector from the alternator. With the ignition OFF you should see the following voltages to ground: BAT - 12 Aux #1 - 0 Aux #2 - 12
2 - CCheck "key on" voltage: With the aux plug still removed, turn the ignition on but don't start the engine. You should see 12 volts at both Aux #1 and #2.
If you don't get the above STOP. Either the wiring is messed up or the alternator idiot light has burned out. It won't charge until the problem is found and fixed.
----
If the above checks out plug the aux terminal back in. Now start the engine, run it up to full throttle for a moment then set throttle back to around 1/3 (1,000 RPM or so). Then:
3 - Take the voltage reading at the alternator BAT terminal. It should be 14 - 14.5 volts. If it's less the problem is the alternator.
4 - To determine whether the internal regulator is the problem, find the regulator shorting tab inside the "D" shaped hole on back of the alternator (photo). With the engine still running at about 1/3 take a small screwdriver touch the tip to the metal tab inside the hole. Now ground the screwdriver shank against the side of the hole. If the voltage jumps to 14 or more with the tab grounded it means the internal regulator is shot. However if still no change the alterator has other problems.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Picking Corn - by Rick Nikolich. It was the day before Christmas shutdown at work and I asked our lead engineering expert Scott Andrzejewski what he was going to do over the holidays. He said that he had some corn that he still needed to pick with an antique one-row New Idea corn picker. Scott has a nice farm about an hour north of Lansing in St. Johns, MI. He wanted to get the rest of his corn in by the next day (Christmas Eve). We had about an inch of new snow on the ground and single digit temperatures. So in the bac
... [Read Article]
Latest Ad:
Sell 1958 Hi-Altitude Massey Fergerson tractor, original condition. three point hitch pto engine, Runs well, photos available upon request
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.