I'm with JimN and John T! By tinkering with the current limiting relay inside the voltage regulator you can dramatically increase generator amp output beyond design spec. However operating it this way is a sure recipe for a generator burnout.
Better to replace the generator with a higher output generator or with an alternator.
However before doing suggest you check ALL the wiring in the generator output circuit: generator ARM to regulator GEN, regulator BAT to ammeter, and ammeter to battery. Even a tiny resistance - less than 0.1 ohm - anywhere in this circuit will seriously limit generator output.
----
FWIW we had an early 60's IHC farm dump that would never charge more than about 15 amps from its 45 amp generator. Replacing generator and regulator made no improvement. Only after removing the instrument panel, discovering an overheated (thus indicating high resistance...) wiring terminal behind the ammeter and replacing it did the problem disappear.
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Choosin, Mounting and Using a Bush Hog Type Mower - by Francis Robinson. Looking around at my new neighbors, most of whom are city raised and have recently acquired their first mini-farms of five to fifteen acres and also from reading questions ask at various discussion sites on the web it is frighteningly apparent that a great many guys (and a few gals) are learning by trial and error and mostly error how to use a very dangerous piece of farm equipment. It is also very apparent that these folks are getting a lot of very poor and often very dangerous advice fro
... [Read Article]
Latest Ad:
Sell 1958 Hi-Altitude Massey Fergerson tractor, original condition. three point hitch pto engine, Runs well, photos available upon request
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.