Henry - If the tractor were mine I'd put a crowbar in my wallet, purchase a new regulator and be done with it (will cost you less than your next replacement battery!)
----
That said, and if you still feel like messing with it, the regulator relay is adjusted by gently bending the spring hanger. It is best accomplished with pair of small needle-nosed pliers. Here's how I've done it:
Make sure the battery is fully charged. Remove the regulator cover. Place a DC voltmeter across the battery. Start the engine and run it at full governed RPM for a couple minutes before proceeding.
Now VERY CAREFULLY grab the regulator spring hanger with needle nose pliers (don't touch anything any other metal with the pliers!). While observing the voltmeter, bend the hanger very slightly to reduce the spring tension.
When the voltmeter reads 7 - 7.25 volts, stop! Let the engine run a minute or two and check the voltmeter reading again. If it's not 7 - 7.25 volts go back and bend the hanger again as needed. It may take several tries to get it to spec.
----
As I mentioned before regulator setting is a fussy, sensitive adjustment. And as "Bob" points out above, one slip with the pliers and the smoke will come out of the regulator - you will wind up buying a new regulator anyway! (Don't ask how I learned this....)
We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today. [ About Us ]
Today's Featured Article - Choosin, Mounting and Using a Bush Hog Type Mower - by Francis Robinson. Looking around at my new neighbors, most of whom are city raised and have recently acquired their first mini-farms of five to fifteen acres and also from reading questions ask at various discussion sites on the web it is frighteningly apparent that a great many guys (and a few gals) are learning by trial and error and mostly error how to use a very dangerous piece of farm equipment. It is also very apparent that these folks are getting a lot of very poor and often very dangerous advice fro
... [Read Article]
Latest Ad:
Sell 1958 Hi-Altitude Massey Fergerson tractor, original condition. three point hitch pto engine, Runs well, photos available upon request
[More Ads]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
