Posted by Bob Mc on September 26, 2012 at 19:27:55 from (99.197.128.57):
Well guys you have convinced me to rethink parting out my newly acquired '55 TO35, so this morning I backed it into the shop to troubleshoot the generator charging problem and lift problem. Now there seems to be a dead short in the starter.
I used the TO35 12 volt generator wiring diagram from FENA. org to check wiring. It is a neg. gnd. 12volt system, the negative battery cable is grounded at the starter mounting bolt. I cleaned all the connections and when I got to the voltage regulator the Load terminal wasn't even connected. So I wired everything according to the schematic. I eliminated all the wiring for the lights and the light switch since there are no lights on the tractor. When I went to start it the solenoid clicked, nothing turned and the battery cables got warm. I thought something must be shorted so I rechecked everything. It was wired as per the schematic. I then disconnected the starter cable at the starter and using a battery cable jumpered straight from the battery positive to the starter post. The sparks flew and the starter did not turn. Shouldn't the starter turn when jumped from the battery like that? I can rock the tractor in gear and the engine turns so it is not locked up. It acts like a dead short in the starter motor, but worked just fine when I started it to bring it into the shop. The only thing I did to the starter during my troubleshooting was remove the cable to clean the contact and post. I don't know if the generator and voltage regulator are even any good, but I wouldn't think they could cause this problem. I'm not an electrician, but I can read a electrical schematic and I'm stumped. Does anyone have an idea? Thanks for any help you can offer.
Same-Day Shipping! Most of our stocked parts ship the same day you order (M-F). Expedited shipping available, just call! Most prices for parts and manuals are below our competitors. Compare our super low shipping rates! We have the parts you need to repair your tractor. We are a Company you can trust and have generous return policies! Shop Online Today or call our friendly sales staff toll free (800) 853-2651. [ More Info ]
All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy
TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.
About this site - Yesterday's Tractors is your one-stop source for antique tractors. If you are interested in older tractors you've come to the right place! Join more than 275,000 other classic tractor enthusiasts from all over the globe. We have many resources for antique tractor enthusiasts available including photos, classified ads, more than 24 tractor discussion forums, a show guide, values, specs and much more. Bookmark this site and come back often. Thanks for stopping by! Feel free to use our feedback form to send us your comments, suggestions and ideas.
