(800) 853-2651
SHOP NOW

Ford 5000 knocking

G

GaryEBolin

New User
Hi guys first time posting on this site.
I have a Ford 5000 and it started knocking this hay season.
It actually sounds like more of a clunk type of sound from down low in the block.
Could the balancer make a sound like this?
Also it looks like I'd have to either pull the engine out or the front end off to remove the oil pan to try and figure out where this noise is coming from.
Thanks Gary
 
There is 2 different gas engines and at least 1 possibly 2 diecel engines
used in the 5000 so if you can give what engine it might help somebody help
you.
 
Hello Gary welcome to YT! To see if it is a rod bearing
pull the plug wire off an each cylinder one at a time
and give it a little rev up. If the rod bearing is going out
the knock will be far less when that cylinder is not
firing. On a diesel crack the injector line on each
cylinder.
 
It could... but start with an injector drop test. Open them one at a time at a fast idle and see if the noise goes away with the
line open. If it does, then I'd swap another injector into the hole where you find the noise goes away with the line open. You
could be dealing with a bad injector, a broken pump plunger spring, bad bearings or a few other things. That said, if the mains or
rods are bad, it should light the oil pressure light at a hot idle..

Rod
 


To get around pulling the front end off you just replace two of those bolts with two that are four inches longer, then after removing the others you slide the bolster ahead on the two long ones.
 
You must log in or register to reply here.

Similar threads

W
Ford 172 diesel squealing noise, no oil pressure, loose harmonic balancer bolt, and white smoke out of breather
3 4 5
Replies
87
Views
4K
Woodtractor1
W
A
Ford 5000 Coolant spitting out
2
Replies
25
Views
760
adnedidas
A
S
ford 5000 new engine? Any advice on where to get?
2
Replies
30
Views
2K
sunnyfield
S
J
Ford 5000 injection pump problems
Replies
3
Views
511
Dieseltech
D
W
Ford 9N Front Knocking
Replies
5
Views
360
Steve@Advance
S
Tractor Parts Tractor Manuals

We sell tractor parts! We have the parts you need to repair your tractor - the right parts. Our low prices and years of research make us your best choice when you need parts. Shop Online Today.

Copyright © 1997-2024 Yesterday's Tractor Co.

All Rights Reserved. Reproduction of any part of this website, including design and content, without written permission is strictly prohibited. Trade Marks and Trade Names contained and used in this Website are those of others, and are used in this Website in a descriptive sense to refer to the products of others. Use of this Web site constitutes acceptance of our User Agreement and Privacy Policy TRADEMARK DISCLAIMER: Tradenames and Trademarks referred to within Yesterday's Tractor Co. products and within the Yesterday's Tractor Co. websites are the property of their respective trademark holders. None of these trademark holders are affiliated with Yesterday's Tractor Co., our products, or our website nor are we sponsored by them. John Deere and its logos are the registered trademarks of the John Deere Corporation. Agco, Agco Allis, White, Massey Ferguson and their logos are the registered trademarks of AGCO Corporation. Case, Case-IH, Farmall, International Harvester, New Holland and their logos are registered trademarks of CNH Global N.V.

Yesterday's Tractors - Antique Tractor Headquarters
Website Accessibility Policy

Back
Top